Generate QR code
Open Access
Subscription Access
Improvement of arrangement for including water-jet ejector in CHP operation cycle
https://doi.org/10.24223/1999-5555-2023-16-1-27-33
Abstract
The question of the reliability of the operation of the exhaust devices almost always remains relevant during the operation of vacuum deaeration plants, since incorrect operation of the exhaust device entails violations of the vacuum deaeration process. As devices for the removal of non-condensing corrosive gases from vacuum deaerators, jet exhaust devices-ejectors are used, in which the kinetic energy of one stream is transferred to another stream by direct contact (mixing). According to the working body, ejectors are divided into water-jet and steam-jet. In this paper, the current scheme of inclusion of a water-jet ejector in the operation cycle of the Ulyanovsk CHP-2 is considered, problems and shortcomings of the scheme are identified, technical devices and their characteristics are described. The results of tests to determine the temperature and flow rate of the source water supplied to the gas separator tank to ensure stable operation of the EV-340 ejector are presented, which showed that the actual flow rate of the source chemically purified water to the gas separator tank is 17 m3/h, and the water temperature in the gas separator tank reaches 37°C, which exceeds the permissible temperature of the working water of the ejector by 7°C. An improved arrangement for the inclusion of a water-jet ejector in the operation cycle of the CHP is proposed, which provides sufficient cooling of the working water of the water-jet ejector by mixing this water with the source water, which is further cooled in the cooling tower. It is estimated that the new improved arrangement gives an economic effect of 2,5 million rubles/year.
About the Authors
M. V. Zolin
Ulyanovsk State Technical University
Russian Federation
Russian Federation
32 Severniy Venets str., 432027, Ulyanovsk
O. V. Pazushkina
Ulyanovsk State Technical University
Russian Federation
Russian Federation
32 Severniy Venets str., 432027, Ulyanovsk
P. I. Kalabanovsky
Ulyanovsk State Technical University
Russian Federation
Russian Federation
32 Severniy Venets str., 432027, Ulyanovsk
References
1. Osintsev K. V., Alabugin A. A., Alekseeva M. S. Multi-criteria modeling of processes and design of the mixing chamber of a steamjet ejector of a condensing turbine. / Bulletin of the South Ural State University. Series: Energy 2020; 20(3): 5 – 16. (In Russ.)
2. Analysis of the possibility of using R718 for a heat pump of a heating system based on a liquid-vapor ejector. S. Sharapov, D. Husiev, V. Kozin, V. Baha, V. Panchenko. / Eastern-European Journal of Enterprise Technologies 2020; 6(8(108)): 39 – 44.
3. Modernization of the scheme of suction of non-condensable gases from the heating water heaters of heating turbines. K. E. Aronson, A. Yu. Ryabchikov, D. V. Brezgin, N. V. Zhelonkin, A. L. Demidov, D. Yu. Balakin, Yu. V. Makhnev, K. A. Tarov. / Power stations. 2022 1092(7): 9 – 14. (In Russ.)
4. Analysis of experimental characteristics of multistage steam-jet electors of steam turbines. K. E. Aronson, A. Y. Ryabchikov, Y. M. Brodov, D. V. Brezgin, N. V. Zhelonkin, I. B. Murmanskii. / Thermal Engineering 2017; 64(2): 104 – 110.
5. Functioning efficiency of intermediate coolers of multistage steam-jet ejectors of steam turbines. K. E. Aronson, A. Y. Ryabchikov, Y. M. Brodov, N. V. Zhelonkin, I. B. Murmanskii. / Thermal Engineering 2017; 64(3): 170 – 175.
6. Reddy L. R. Numerical investigation of ejectors for ejector vefrigeration system. / lnternational Journal of Innovative Science and Research Technology 2018; 3(5): 166 – 171.
7. Pazushkina O. V., Zolin M. V. Assessment of the modernization of the inclusion of gas exhaust devices of vacuum deaerators. / Proceedings of Academenergo 2020; (3): 60 – 73. (In Russ.)
8. Pazushkina O. V., Zolin M. V. Assessment of the effectiveness of the use of water jet ejectors at thermal power plants. / Industrial Energy 2021; (3): 34 – 38. (In Russ.)
9. Pazushkina O. V., Zolin M. V. Operation of deaeration devices in the water treatment cycle at heat sources. / Energy saving and water treatment 2021; 5 (133): 4 – 12. (In Russ.)
10. Patent No. 2789762. Russian Federation, IPC C 02 F 1/20 Vacuum deaeration unit. / O. V. Pazushkina, M. V. Zolin, M. M. Zamaleev, P. I. Kalabanovskiy; applicant and patent holder Ulyan. state tech. un.-t. – No. 2022112815; dec. 05/12/2022; publ. 09.02.2023 // Bull. No. 4. (In Russ.)
Review
For citations:
Zolin M.V., Pazushkina O.V., Kalabanovsky P.I. Improvement of arrangement for including water-jet ejector in CHP operation cycle. Safety and Reliability of Power Industry. 2023;16(1):27-33. (In Russ.) https://doi.org/10.24223/1999-5555-2023-16-1-27-33
Views:
310
Email this article 
